Posted: December 1st, 2012 | Author: eliza | Filed under: bathroom, oops, plumbing, progress, upstairs bathroom, water | No Comments »
Have I told you about the upstairs bathroom? There are a few stories to tell. We’ve learned that this bathroom was originally built by a previous owner, obviously another amateur do-it-yourselfer who invented a few creative (and not-to-code) plumbing techniques, like putting the sink trap (normally found directly under the sink) two stories down, in the basement. The next owners apparently had some bathroom problems because when we got here, the whole bathroom floor was covered in a thin film of foul, sludgy sewage residue, including the baseboards and, in some areas, the bottom of the wainscoting. And the toilet looked like this. UGH. Until I scrubbed it for a few DAYS, then it looked like this. (While I was working on the plumbing I discovered a pair of childrens’ safety scissors lodged in the drain-pipe, which might have been the root of the problem!) So back in 2010 I tore out all the flooring (while wearing rubber gloves and a mask!) and the baseboards and the nasty parts of the wainscoting. When I got down to the sub-flooring, I was pleased to find that it was clean, unsoiled and usable! So we left it like that, and cleaned the bejeezus out of everything else, and we’d been living without proper flooring in the bathroom ever since.
The shower stall was ugly but once we replaced the burst pipes and turned on the water, it seemed to work fine and we weren’t planning to replace it til we’d fixed up the rest of the house. And then around June, we sprung a leak! Downstairs, in our beautiful new bathroom, there was water coming out of the ceiling! It ruined some of the fresh new paint and plaster on the downstairs wall, which was kind of heartbreaking. We disconnected the water supply to the shower and set about searching for the leak. Because of the unorthodox and not-to-code nature of the plumbing situation, it was actually impossible to access the shower plumbing without either tearing out the plaster wall of the adjacent hallway, or else tearing out the shower stall itself. Unsure of the exact location of the problem, we decided to just bite the bullet and tear out the old shower stall. And when we did, we found no apparent source of the leak! Arghhhhhh. We inspected very carefully around every seam of the supply line and the drain line, and we could not find any moisture, nor any water stains or signs of leaking. Instead there was plenty of powdery, dry dust, which really seemed to suggest that there was never any leaking at all. Looking back on the situation now, I believe that the leak was not caused by plumbing problems in the shower, nor by cracks in the shower stall, but by water spraying out of the shower, on to the porous, unfinished floor and seeping down through the first-floor ceiling below. Oooops.
But we’d hacked up the old shower stall in the process of removing it, so we needed a new shower stall. After way too many days of living with no shower (thankfully we have a generous neighbor who let us use his shower!), we borrowed my parents’ pickup truck and headed to Home Depot to pick out our new shower stall. Hauled it home and wrestled it onto the front porch and … oops again! It won’t fit through the front door! And it won’t fit through the bathroom door either.
Next day we hauled it back to Home Depot and exchanged it for a two-part model that did fit through the front door. But it turned out to be a tiny bit larger than the old shower stall, so we had to rip out a partial wall (the one that supported the third side of the shower stall) to get it in. It was a pretty simple thing, it wasn’t a load-bearing wall, so it wasn’t a huge deal, but after we got the shower stall in, then we were missing that wall and it needed to be replaced.
It also seemed like a good time to replace the bathroom flooring, so we started researching Marmoleum, which my sister had used in her bathroom renovation, and seemed like the best and easiest solution. Marmoleum is the original brand of linoleum, which has made a comeback in the past few years as a green building material. It’s made from natural linseed oil, pine rosins and wood flour, without all the toxic ingredients that go into vinyl flooring. It comes in large sheets which are waterproof (except for the seams between sheets) and unlike tile it feels soft and warm under bare feet, which is important when you live in a big old drafty farmhouse in Maine!
We had to hire help for installing the marmoleum. Before he could get started, we had to remove all the fixtures from the bathroom (except for the new shower, of course).
Here’s the finished floor! It’s purple! It wasn’t my first choice for a bathroom floor color, but it was the only one we could agree on at all.
Once the floor was in, we put the toilet and sink back in, of course, and started planning for the next stage, re-building the shower wall and the corner soffit that we’d ripped out.